A6 Quattro Sedan V6-3.0L (AVK) (2002)
-
With ignition switched off, disconnect battery Ground (GND) cable -arrow-.
All:
-
Open fuel filler cap briefly and close again
-
Remove rear seat bench.
-
Remove screws -arrows- for the cover.
-
Carefully release 4-pin harness connector and disconnect.
WARNING:
-
Fire Hazard. Do not smoke, work near heaters or have anything in the area that could ignite the fuel or fumes.
-
Fuel supply lines are under pressure. Before loosening any lines, cover the connection with a rag. Release the pressure by slowly
separating the connection.
-
Mark fuel supply line -1- and return line -2- and disconnect from closing flange (right side).
WARNING: The closing flange should only be opened if the fuel tank is maximum 1/4 full. Otherwise large quantities of fuel escape. Drain fuel
tank if necessary.
-
Remove closing ring for sender for fuel gauge using 3087 wrench.
-
Remove closing flange and seal from tank opening.