Allroad Quattro V8-4.2L (BAS) (2004)
/Page-2952001.png)
Fluid - Transfer Case: Service and Repair
Gear Oil In Transfer Case, Changing or Topping Up After Repair
5 SPD. A/T 01L AWD
Gear oil in transfer case, changing or topping up after repair
Special tools and equipment
^
VAG 1306 Drip tray
^
Remove right catalytic converter from rear exhaust system and press rear of catalytic converter toward right.
Drain gear oil
^
Place VAG 1306 drip tray underneath.
^
Remove drain plug (arrow A) and drain gear oil.
^
Install drain plug (arrow A) again.
Note: Always replace drain plug.
Fill up gear oil
^
Remove check screw (arrow
^
Fill up gear oil. Specification and capacity.
^
Re-install check screw (arrow -B-).
^
Perform a short road test and then check gear oil in transfer case and if necessary, top up
Note: It is only sure that the newly filled gear oil has penetrated into the Torsen differential after a short road test
Tightening torques
Check screw M 18 in transfer case housing ................................................................................................................................................................ 35 Nm
