Electra V6-181 3.0L (1985)
Fluid Line/Hose: All Technical Service Bulletins
Warranty Information
Dealers are to submit each campaigned vehicle as a separate case on the one-line warranty document form S-764. Dealers submitting warranty claims by
teletype terminal are to transmit campaign completions as a separate case also.
LIST THE ONE APPLICABLE LABOR OPERATION
SUBLET
PART
FAILED
PARTS
FAILURE
LABOR
LABOR
*OTHER DEALER
OPER.
COUNT PART NO. ALLOW.
CODE
OP. NO.
HOURS
HOURS MTL. TWG.
^
Inspect Battery
Only
--
--
--
96
V2660
.2
.1
+++
^
Inspect, Replace Battery and Transmission Cooler Hoses.
2
1981590
++
96
V2661
.5
.1
+++
^
Same as Oper. # V2661 plus Clean-up Components
2
1981590
++
96
V2662
.9
.1
+++
^Same as Oper.# V2662 plus Replace Power Steering Cooler Pipe
3
1981590
++
96
V2663
1.3
.1
+++
*
.1 hour for Administration.
++
List current dealer price plus 30% of parts replaced less scrap
allowance of $1.95 for replaced battery.
+++
List amount for items required such as sodium bicarbonate (baking
soda), Fluids (Power Steering, Transmission, Engine Coolant), Paint,
and Washer Hose.
NOTE:
Add to applicable above labor hours, as required.
^
Replace washer hose = .1 hr.
^
Replace upper radiator hose = .2 hrs.
^
Recoat affected parts = .6 hrs.
(Radiator support, radiator, battery tray).
^
Replace hood release cable = .3 hrs.
THE FOLLOWING LABOR OPERATION IS ONLY TO BE USED WHEN ADDITIONAL PARTS AND/OR LABOR ARE REQUIRED AND
ZONE AUTHORIZATION HAS BEEN OBTAINED.
SUBLET
PART
FAILED
PARTS FAILURE LABOR LABOR *OTHER DEALER
OPERATION COUNT PART NO. ALLOW. CODE OP. NO.
HOURS HOURS MTL TWG
^
Includes all items.
In oper V2663 plus additional parts and/or labor authorized by Zone.
X
1981590
XX
96
V2664
XXX . 1 hr.
xxxx
*
.1 hr. for administration.
x
List number of parts replaced.
xx
List current dealer price plus 30% of all parts replaced less scrap
allowance of $1.95 for replaced battery.
xxx
List labor time authorized (includes total time allowed for
oper. V2663, plus additional time authorized to complete repairs).
xxxx
List amount for items required, such as sodium bicarbonate (baking
soda), fluids, (power steering, transmission, engine coolant), paint
and washer hose.
To assure accurate records of all transactions on this campaign, it is recommended that campaign repairs for each vehicle be listed on a separate repair
order. Other repairs performed to the vehicle may be listed on the same repair order, and warranty cases other than campaigns may be listed on the
same warranty document.
Dear Buick Owner:
General Motors has determined that some 1985 Electra Coupes and Sedans were assembled with batteries that may leak acid. This acid may cause
