Enclave FWD V6-3.6L (2008)
Seals and Gaskets: By Symptom
Technical Service Bulletin # 09-07-30-006
Date: 090309
A/T - Fluid Leak From Torque Converter Housing
TECHNICAL
Bulletin No.: 09-07-30-006
Date: March 09, 2009
Subject:
Transmission Fluid Leak Due to Transmission Converter Housing Seal (Inspect with Dye and Black Light, Replace Torque Converter Fluid Seal)
Models:
2008-2009 Buick Enclave
2008-2009 Chevrolet Equinox, Malibu
2009 Chevrolet Traverse
2007-2009 GMC Acadia
2007-2009 Pontiac G6
2008-2009 Pontiac Torrent
2007-2009 Saturn AURA, OUTLOOK
2008-2009 Saturn VUE
Equipped with a 6T70/75 Automatic Transmission (RPO MH2, MH4, MH6, MY9)
Condition
Some customers may comment about an oil leak. Upon further investigation, the technician may find a transmission oil leak at the transmission converter
housing or transmission case to housing, at the gasket, or at the rear lower engine oil pan bolts.
Correction
1. Verify that the transmission has a fluid leak. Refer Fluid Leak Diagnosis Dye and Black Light Method in SI. Carefully inspect with the black light to
check the axle seals. Make sure oil from the axle seal leak isn't running down the case and ending up on the case to housing split line.
2. Inspect the converter housing to oil pan weep hole and the two lower rear engine oil pan bolts with a black light. If either location shows leakage with
dye, the source is most likely the torque converter hub seal.
3. Remove the transmission. Refer to Transmission Removal in SI.
4. Once the transmission is removed from the vehicle, inspect with the black light to ensure that the leak is coming from the torque converter fluid seal.
Install a new seal assembly, GM P/N 24249775. Refer to Torque Converter Fluid Seal Replacement in SI.
Parts Information
Warranty Information
Disclaimer
Technical Service Bulletin # 01-07-30-032E
Date: 080929
