LaCrosse V6-3.8L VIN 2 (2005)
Water Pump: Customer Interest
Engine - Chirp Noise from Engine Compartment
TECHNICAL
Bulletin No.: 08-06-01-009A
Date: September 18, 2009
Subject: Chirp Noise from Engine Compartment (Replace Accessory Drive Belt and Water Pump Pulley)
Models:
2005-2009 Buick Allure (Canada Only), LaCrosse
2006-2008 Buick Lucerne
2005-2008 Pontiac Grand Prix
Equipped With Engine RPOs L26, L32
Please Refer to GMVIS
Supercede:
This Bulletin is being revised to add the 2009 Allure/LaCrosse models. Please discard Corporate Bulletin Number 08-06-01-009 (Section 06 - Engine).
Condition
Some customers may comment on a chirp or noise coming from the engine compartment. Upon inspection, technicians may find that the noise is coming
from the accessory drive belt that powers the water pump, power steering pump, alternator and other components.
Important
This is NOT the drive belt that powers the supercharger in supercharger-equipped vehicles.
Cause
This condition may be caused by a slight variation in the alignment of the accessory drive pulleys. When this variation occurs, it causes the accessory
drive belt to shift slightly inwards or outwards.
Correction
The belt currently available from GMSPO is made of an improved material that reduces noise while maintaining durability. The new water pump pulley
features a revised crown. The revised crown, which is the surface that the back side of the belt contacts, is flatter and allows for better belt positioning
due to pulley alignment variation. Replace the accessory drive belt and water pump pulley on affected vehicles. Refer to Engine Mechanical - 3.8L
subsection of SI for accessory drive belt and water (coolant) pump pulley procedures.
Parts Information
Warranty Information
For vehicle repaired under warranty, use the table above.
