Regal V6-3.8L VIN K (1997)
Wiring Harness: Customer Interest
Electrical - SES Lamp ON/Driveability/No Start/DTC's Set
Bulletin No.: 00-06-04-049B
Date: December 19, 2003
TECHNICAL
Subject:
Various Driveability Symptoms - Malfunction Indicator Lamp (MIL) Illuminates Intermittently, ABS Light On, DTCs Set, Engine Will Not Start (Repair
Wire(s))
Models:
1997-2003 Buick Century, Regal Built Prior to 2/03
2000-2003 Chevrolet Impala, Monte Carlo Built Prior to 2/03
1999-2001 Pontiac Grand Prix Built Prior to 10/1/00 - VIN Breakpoint 1F136536
Supercede:
This bulletin is being revised to add additional models and model years and to include possible ABS indicator illuminated. Please discard Corporate
Bulletin Number 00-06-04-049A (Section 06 - Engine).
Condition
Some customers may comment on one or more of the following conditions:
^
Anti-Lock Brake System Warning Light illuminated
^
Intermittent MIL/Service Engine Soon indicator illuminated
^
Engine will not start
^
Engine stalls after start up
^
Various electrical system failures
^
Various driveability concerns
Cause
These conditions may be caused from the engine wiring harness chaffing against the mounting ring on the A/C accumulator. This contact may cause a
rub through to the wires enclosed in that harness, resulting in the above conditions. Damage to the harness may also result in several stored diagnostic
trouble codes.
Correction
Inspect and repair any damaged wires. Use the procedure listed below.
Note:
Do not install plastic conduit over the repaired area. Doing so may damage the A/C accumulator.