Terraza FWD V6-3.5L VIN 8 (2005)
PROM - Programmable Read Only Memory: All Technical Service Bulletins
Engine Controls - Extended Hot Start Crank Time
Bulletin No.: 06-06-04-049
Date: September 22, 2006
TECHNICAL
Subject:
LX9 Engine Only, Intermittent Extended Crank Time On Hot Engine Restart, Starter Motor May Not Disengage After Engine Start (Reprogram PCM)
Models:
2005-2006 Buick Rendezvous, Terraza
2004-2006 Chevrolet Malibu, Malibu Maxx
2005-2006 Chevrolet Uplander
2005-2006 Pontiac G6, Montana SV6
2005-2006 Saturn Relay
with 3.5L V6 Engine (VIN L, 8 - RPO LX9)
Attention:
This bulletin only applies to vehicles with EGR valves produced by Delphi. Vehicles built with Seimens EGR valves (production or service) already
have the latest calibration.
The PCM calibration to address this concern for 2006 vehicles listed in this bulletin will be available in the October 2006 broadcast.
Condition
Some customers may comment on an intermittent extended crank time on hot engine restart and the starter motor may not disengage after engine start.
Correction
Before reprogramming the PCM, verify the customer concern. Refer to Diagnostic System Check - Vehicle in Vehicle Control Systems in SI. Follow the
diagnostics for a possible cause of an extended crank time in hot engine restart. If no trouble is found, reprogram the PCM.
Reprogram the PCM with the latest calibrations if the above concern is encountered. An updated PCM calibration is now available to address this
concern. This calibration, or any that follow, is designed to address this concern. Refer to Service Programming System (SPS) using the appropriate
Service Information (SI) procedures. The new PCM calibrations will be available to dealerships in TIS2Web (website version of TIS) version 9.5 for
2006 beginning 9/18/06. If you cannot access the calibration, call the Techline Customer Support Center and it will be provided. As always, make sure
your Tech 2(R) is updated with the latest software version.
Warranty Information
For vehicles repaired under warranty, use the table.
