Terraza FWD V6-3.5L VIN 8 (2005)
Window Seal: Customer Interest
Body - Door Glass Inoperative
Bulletin No.: 05-08-64-009
Date: March 31, 2005
TECHNICAL
Subject:
Door Glass Inoperative (Replace Door Glass Insulator/Sash, If Necessary)
Models:
2005 Chevrolet Uplander
2005 Buick Terraza
2005 Pontiac Montana SV6
2005 Saturn Relay
Condition
Some customers may comment that the door glass is inoperative.
Cause
The door glass may have frozen to the window run channel, and when cycled down, caused damage to the door glass insulator or sash channel.
Correction 1
Replace the window insulator following the procedure below:
1.
Lower the door glass.
2.
Remove the door trim.
3.
Remove the water deflector.
4.
Using a small flat-bladed tool, press in on the retainer tabs to release the door glass from the sash channel.
5.
Slide the channel forward.
6.
Push the door glass up and tape it to the door frame.
7.
Use a small flat-bladed tool to remove the window insulator from the glass.
8.
Install the new insulator to the glass.
9.
Remove the tape from the glass and lower the glass.
10.
Slide the sash channel back in place and lock it to the insulators on the glass
11.
Install the water deflector.
12.
Install the door trim.
Correction 2
Replace the sash channel, if necessary, by following the procedure below:
1.
Remove the door glass from the sash channel. Follow the procedure in Correction 1 for removal of the door glass from the sash channel.
2.
Bend the channel end back.
3.
Remove the sash channel from the window regulator by moving it forward. The wheel on the regulator will disengage from channel in the rear. Lift
the channel on an angle and move the channel rear ward. This will disengage the front wheel from the channel. Then remove.
4.
Install the sash channel. Lift it on an angle and engage the front wheel of the window regulator. Lower the channel and move it rearward to engage
