Caprice RWD V8-305 5.0L (1992)
Weatherstrip: All Technical Service Bulletins
Front Door/Rocker - Mud Build-Up
Group Ref.: Body
Bulletin No.: 431006
Date: February, 1994
SUBJECT:
DIRT BUILD-UP ON ROCKER AND LOWER INBOARD DOOR SURFACE (INSTALL FOAM SEAL)
MODELS:
1992-94 BUICK ROADMASTER
1992-94 CADILLAC FLEETWOOD
1991-94 CHEVROLET CAPRICE
1991-92 OLDSMOBILE CUSTOM CRUISER
CONDITION:
Some owners may express dissatisfaction with mud collected along inside bottom of front door and rocker.
CORRECTION:
Install new foam seal, P/N 10249066, (when ordering two (2) pieces are required), one for left hand front door and one for right hand front door. Follow
procedures listed below for installation:
1.
With the front doors fully open, clean the inside door surface just forward of the front inboard drain hole using one of the following adhesive
cleaners:
3M*: General Purpose Adhesive Cleaner P/N 08984
American Sure Seal*: Urethane Cleaner P/N CUSH
Kent*: Acrysol 20005
2.
After cleaning with above, wipe clean with 50/50 solution of isopropyl alcohol and water.
3.
Surface should be 65~F (18 degree C) or higher.
4.
Remove protective backing from foam seal P/N 10249066.
