Malibu L4-2.2L VIN F (2005)
Ignition Coil: All Technical Service Bulletins
Steering - Increased Cold Start Up Steering Effort
Bulletin No.: 05-02-32-001C
Date: January 17, 2007
TECHNICAL
Subject:
Increased Steering Effort on Cold Start-up (Replace Lower Control Arms)
Models:
2004-2005 Chevrolet Malibu
2005 Pontiac G6
Supercede:
This bulletin is being updated to revise the labor time information. Please discard Corporate Bulletin Number 05-02-32-001B (Section 02 - Steering).
Condition
Some customers may comment on increased steering effort for a few seconds just after starting the vehicle. This condition occurs when the outside
temperatures are under 10°F (-12°C). This condition is short in duration and does not set a code. In many instances, it will not be possible to duplicate
the customer's concern unless temperatures are below 10°F (-12°C).
Cause
This condition may be caused by additional resistance in the lower control arm ball stud when cold.
Correction
To aid in installation of the lower control arms, loosely start all bolts to hold the assembly in place and then tighten to the correct torque specification.
On the right side of the vehicle, it is necessary to remove the wheel well splash shield and the engine splash shield.
REPLACE BOTH FRONT SUSPENSION LOWER CONTROL ARMS. Refer to Lower Control Arm Replacement in SI.
Parts Information
Warranty Information
