TrailBlazer 2WD L6-4.2L VIN S (2003)
Window Seal: Customer Interest
Body - Front/Rear Side Door Glass is Scratched
Front or Rear Side Door Glass Scratched (Adjust Hem Flange)
# 04-08-64-012C - (May 26, 2005)
Models:
2004 Buick Rainier
2002-2004 Chevrolet TrailBlazer, TrailBlazer EXT
2002-2004 GMC Envoy, Envoy XL
2004 GMC Envoy XUV
2002-2004 Oldsmobile Bravada
This bulletin is being revised to correct the model designations for the last four parts listed in the Parts Information table. Please discard Corporate
Bulletin Number 04-08-64-012B (Section 08 -- Body and Accessories).
Condition
Some customers may comment that the front or rear door glass has some vertical scratches on the outside of the door glass.
Cause
The inner and outer belt moldings may be too tight, causing dirt to get impregnated into the outer belt molding and causing scratches.
Correction
1.
Remove the Door Trim Panel-Side Front Door. Remove the outer belt molding.
2.
Take a measurement between the inner and outer hem flange at the top of the door. Refer to the illustration above. If that measurement is 27 mm
(1.06 in) or lower, proceed to step 3.
3.
Close the door.
4.
Wearing gloves, pull on the outer door skin to achieve a measurement of 28 mm (1.10 in) minimum to 31 mm (1.22 in) maximum. If the
measurement cannot be achieved by pulling, use a pair of Vise Grip (Sheet Metal) pliers and bend the outer panel to get your measurement.
5.
Install a new reveal molding.
6.
Install a new door glass.
