Uplander FWD V6-3.5L VIN L (2006)
Wheel Cover: Customer Interest
Wheels - Wheel Cover Clicking/Ticking Noises
Bulletin No.: 05-03-10-013B
Date: March 29, 2007
TECHNICAL
Subject:
Rattle/Click/Ticking Type Noise Coming From Wheel Cover (Install Wheel Cover Insulators)
Models:
2005-2006 Buick Allure (Canada Only), LaCrosse with 16 Inch Wheel Cover
2005-2006 Buick Terraza with 17 Inch Wheel Cover
2005-2006 Chevrolet Equinox with 16 Inch Wheel Cover
2006 Chevrolet HHR with 16 Inch Wheel Cover
2005-2006 Chevrolet Uplander with 17 Inch Wheel Cover
2005-2006 Pontiac Montana SV6 with 17 Inch Wheel Cover
2005-2006 Saturn Relay with 17 Inch Wheel Cover
Supercede:
This bulletin is being revised to update the parts information. Please discard Corporate Bulletin Number 05-03-10-013A (Section 03 - Suspension).
Condition
Some customers may comment on a rattle/click/ticking type noise coming from the front or rear wheels. This condition is most apparent while driving at
low speeds (0-24 km/h (0-15 mph)) and is relative to wheel rotation.
Cause
This condition may be caused by hard contact between the inner edge of the wheel cover and the outer edge of the steel rim. This contact occurs when
the delrin ring comes out of its channel and separates from the wheel cover. In most cases, the delrin ring will be completely gone.
Correction
If the delrin ring is missing, install insulators on the backside of all four wheel covers. Use the following service procedure listed below.
Remove the wheel covers.
Clean the back side of each wheel cover using a mild liquid detergent in a distilled or deionized water solution. Rinse each wheel cover with clean water.
Dry each wheel cover using compressed air or a clean, lint-free, non-abrasive cloth.
