Uplander FWD V6-3.5L VIN L (2006)
Wiper Motor: All Technical Service Bulletins
Body - Buzz or Rattle Noise from Rear Liftgate On Bumps
Bulletin No.: 07-08-59-005
Date: June 27, 2007
TECHNICAL
Subject:
Buzz or Rattle Noise from Rear Liftgate While Driving Over Rough Surfaces/Bumps (Install Foam Between Rear Wiper Motor and Liftgate)
Models:
2005-2007 Buick Terraza
2005-2007 Chevrolet Uplander
2005-2007 Pontiac Montana SV6
2005-2007 Saturn Relay
with Rear Window Wiper System (RPO C25)
Condition
Some customers may comment on a buzz or rattle noise coming from the rear of the vehicle or liftgate while driving over rough surfaces/bumps.
Cause
The cause may be from a lack of clearance between the rear wiper motor and the liftgate.
Correction
Install foam between the rear wiper motor and the rear liftgate using the steps below:
Verify that the noise is coming from the rear liftgate.
Remove the rear liftgate trim panel. Refer to Liftgate Trim Panel Replacement in SI.
Cut a piece of closed cell foam, P/N P46510, to 25 mm (1 in) width by 30 mm (1-1/8 in) length.
Loosen the two rear wiper assembly bolts.
Do Not completely remove the rear wiper assembly bolts.
Slightly pull down on the rear wiper motor to locate the witness mark (1) on the liftgate.
