300 V6-3.5L (2008)
NOTE: LHD model shown. RHD model similar.
14. Disconnect and isolate the negative battery cable.
15. Recover the refrigerant from the refrigerant system See: Service and Repair/Refrigerant System Recovery.
16. On LHD models, remove the air cleaner housing See: Engine, Cooling and Exhaust/Engine/Tune-up and Engine Performance Checks/Air Cleaner
Housing/Service and Repair/Air Cleaner Housing - Removal.
17. Remove the nut (6) that secures the front section of the A/C liquid line (8) to the rear section of the liquid line (10).
18. Disconnect the front section of the A/C liquid line from the rear section of the liquid line and remove and discard the dual plane seal.
19. Install plugs in, or tape over the opened liquid line fittings.
20. Remove the nut (7) that secures the front section of the A/C suction line (9) to the rear section of the suction line (12).
21. Disconnect the front section of the A/C suction line from the rear section of the suction line and remove and discard the dual plane seal.
22. Install plugs in, or tape over the opened suction line fittings.
23. Disconnect the wire harness (3) from the A/C pressure transducer (2).
24. Remove the bolt (5) that secures the refrigerant line mounting bracket to the left front shock tower (4).
25. Remove the nut (11) that secures the liquid and suction line tapping block (13) to the A/C expansion valve (1).
26. Disconnect the rear section of the A/C liquid and suction lines from the A/C expansion valve.
27. Remove the dual plane seal from the suction and liquid line fittings and discard.
28. Install plugs in, or tape over the opened suction and liquid line fittings and the expansion valve ports.
29. Remove the rear section of the A/C liquid and suction lines as an assembly from the engine compartment.
30. If required, remove the A/C pressure transducer from the rear section of the A/C liquid line See: Refrigerant Pressure Sensor / Switch/Service and
Repair/Removal.
Suction Line
REMOVAL
WARNING: Refer to the applicable warnings and cautions for this system before performing the following operation See: Service
Precautions/Warning and See: Service Precautions/Caution. Failure to follow the warnings and cautions could result in possible personal
injury or death.
NOTE: The A/C suction line is serviced in two sections. The rear section of the suction line is serviced as an assembly with the rear section of
the A/C liquid line.
FRONT SECTION
