Avenger L4-2.0L DOHC (1995)
4.
Type or print (with a ball point pen) the following information on the Authorized Modifications Label and attach the label near the VECI label
(Figure 4).
G. Complete Proof of Correction Form
1.
For vehicles involved in Recall # 7672 located in California only: Complete a Vehicle Emission Recall Proof of Correction Form and supply it to
the vehicle owner.
Dealer Letter
IMPORTANT
DEALER SERVICE INSTRUCTIONS
Emissions Recalls # 7671 and # 7672
Fuel Pressure Regulator, Aspirator System and Reprogram PCM
^
This service requirement applies only to 1995 model year Dodge Avenger, Chrysler Sebring and Eagle Talon (FJ) vehicles equipped with a 2.0L
DOHC (non-turbo) engine ("Y" in the 8th VIN position), manual transmission and a:
^
Federal Emission Control System (Sales Code -- NAA) -- Recall # 7671
^
California Emission Control System (Sales Code -- NAE) -- Recall # 7672
^
NOx emission levels on the above listed vehicles, may not comply with U.S. Environmental Protection Agency (EPA) or California Air Resources
Board (CARB) emission regulations. In addition, a spring in the fuel pressure regulator may fail. To correct these conditions, the fuel pressure
regulator must be replaced, the exhaust aspirator system must be removed and the powertrain control module (PCM) must be reprogrammed or if
necessary, replaced.
^
For vehicles involved in Recall # 7672: Be sure to provide a Vehicle Emission Recall Proof of Correction Form (Form No. 81-016-1053) to each
California vehicle owner upon completion of the recall service, for owner use as proof during renewal of the vehicle registration.
^
The PCM software that is loaded during the recall service procedure also includes any other PCM updates that may have been released (i.e. TSB's)
between the date of manufacture and the issuance of the TIL CD update that was used.
Alternate Transportation:
^
If inspection determines that PCM replacement is required and the vehicle must be held overnight, dealers should attempt to minimize customer
inconvenience by placing the owner in a loaner vehicle.
Parts Packages:
^
Each involved dealer, to whom vehicles in the recall were invoiced, will receive enough Pressure Regulator and Aspirator Packages to service 25%
of those vehicles.
Owner Letter
EMISSIONS RECALL TO REPLACE YOUR VEHICLE'S FUEL PRESSURE REGULATOR, REMOVE THE ASPIRATOR SYSTEM AND
REPROGRAM THE POWERTRAIN CONTROL MODULE
Dear Avenger, Sebring or Talon Owner:
It has been determined that some 1995 Dodge Avenger, Chrysler Sebring and Eagle Talon vehicles equipped with a 2.0L DOHC (non-turbo) engine and
a manual transaxle, may be in violation of California Emissions Standards.
