Avenger L4-2.0L DOHC (1995)
Ignition Cable: Customer Interest
Ignition System - Engine Misfire
NO: 18-17-95 Rev. A
GROUP: Vehicle Performance
DATE: May 26, 1995
SUBJECT:
Engine Miss
THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 18-17-95 DATED MAY 12, 1995 WHICH SHOULD BE REMOVED FROM
YOUR FILES. ADDITIONAL PARTS HAVE BEEN ADDED. ALL REVISIONS ARE MARKED WITH **ASTERISKS**.
MODELS:
1995 (FJ) Avenger/Sebring/Talon
1995 (PL) Neon
NOTE:
THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MAY 1, 1995, (MDH 05-01-XX) EQUIPPED WITH A 2.0L DOHC
NON-TURBO ENGINE.
SYMPTOM/CONDITION:
Engine miss at idle and/or under load. This condition may occur on vehicles with less than 5,000 miles. The "Check Engine Light" may be illuminated
and Diagnostic Trouble Code (DTC) "CYLINDER # 1 OR # 2 OR # 3 OR # 4 MISFIRE" or "MULTIPLE CYLINDER MISFIRE" may be present.
DIAGNOSIS:
Remove affected cylinder spark plug(s) and inspect for "carbon tracking" on spark plug insulator and inside spark plug wire boot. The tracking would
appear as one or more black lines running down the side of the spark plug ceramic insulator and/or a gray/white track down the inside of the spark plug
boot on the ignition wire. If tracking is evident, proceed to the repair procedure.
PARTS REQUIRED:
4
4671057
Spark Plug (RC-9-YC), PL
**4
5269556
Spark Plug (RC-9-YC5), FJ**
1
4773841
Spark Plug Cable Set
REPAIR PROCEDURE:
This bulletin involves replacing all four spark plugs and cables.
** Remove and install four spark plugs, P/N 4671057 for PL models or P/N 5269556 for FJ models, and spark plug cable set, P/N 4773841, as outlined
in the appropriate Service Manual. **
POLICY: Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
Labor Operation No:
08-17-02-90
0.4 Hrs.
FAILURE CODE: P8 - New Part
