Daytona V6-181 2972cc 3.0L SOHC VIN 3 FI (1992)
Body Controller: Customer Interest
Intermittent Operation of Body Controller Functions
NO.:
08-05-92 Rev. A
GROUP:
Electrical
DATE:
Aug. 10, 1992
SUBJECT:
Intermittent Operation Of Power Door Locks, Chimes Intermittent Wipers, EVIC (Body Controller Functions)
THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-05-92 WHICH SHOULD BE REMOVED FROM YOUR FILES. THE
AS-BODY APPLICATION HAS BEEN REMOVED FROM THIS BULLETIN. REFER TO TECHNICAL SERVICE BULLETIN 08-14-92 FOR
AS-BODY APPLICATION. ADDITIONAL CHANGES ARE HIGHLIGHTED WITH **ASTERISKS**.
MODELS:
1992 (AG) Daytona (AJ) Lebaron Coupe/Lebaron Convertible
SYMPTOM/CONDITION:
Vehicles may experience a loss and or intermittent operation of body controller function (power door locks, intermittent wipers, chimes, gauges, EVIC,
illuminated entry, indicator lamps, cluster lighting). The vehicles relays may be causing a voltage spike which temporarily affects the body controller.
Vehicles experiencing any of these conditions should have the following procedure performed.
PARTS REQUIRED:
As Required
Relay
4728987
REPAIR PROCEDURE:
This procedure involves inspection and replacement of the vehicle relays (up to 15 relays per vehicle) as required.
1.
Inspect all relays for part number 4671001.
2.
All relays with PN 4671001, as shown in Figure 1, should be replaced with a new relay PN 4728987. Relays are located in the Power Distribution
Center (located in engine compartment) and in the Relay Block (located below the dash at the left kick panel).
3.
After all suspect relays have been replaced, disconnect and reconnect the battery.
4.
Using the DRB II check for any body controller faults (in the Body Controller Menu select "READ FAULTS").
5.
If the DRB II reads "NO FAULTS DETECTED", the repair procedure is complete.
6.
If the DRB II reads "EEPROM CHECKSUM ERROR", replace the body controller. **Contact your local Huntsville feature product service
center to order an exchange body controller.**
7.
Any other faults that are detected should be diagnosed using the appropriate 1992 diagnostic procedures manual.
POLICY
Reimbursable within the provisions of the warranty.
