Grand Caravan FWD V6-3.3L VIN 3 Flex Fuel (2002)
Door Module: All Technical Service Bulletins
Body - Sliding Door/Liftgate Erratic Operation
NUMBER: 23-041-02
GROUP: Body
DATE: Sept. 16, 2002
THIS BULLETIN IS BEING PROVIDED IN ADVANCE. THE MDS2 MUST BE OPERATING WITH CIS/ISIS CD2118 OR HIGHER
AVAILABLE OCTOBER 14, 2002.
SUBJECT:
Power Sliding Door and/or Power Liftgate Will Pop Off but Not Power Open
NOTE:
THIS BULLETIN SHOULD BE PERFORMED ON ALL IN STOCK VEHICLES BUILT BETWEEN NOVEMBER 1, 2001 (MDH110/XX) AND
AUGUST 31, 2002 (MDH 0831XX).
OVERVIEW:
This bulletin involves flashing each Power Sliding Door (PSD) and/or Power Liftgate (PLG) module(s) and resetting obstacle detection values.
MODELS:
2002 - 2003
(RS)
Town & Country/Caravan/Voyager
2002 - 2003
(RG)
Chrysler Voyager (International Markets)
SYMPTOM/CONDITION:
When opening the PSD and/or PLG using the Remote Keyless Entry (RKE), overhead console switch, or B pillar switch, the PSD and/or PLG may "pop
off" but not power open. The power close feature will operate correctly.
DIAGNOSIS:
If the customer describes the above symptom/condition and the Diagnostic Trouble Code (DTC) is INCOMPLETE POWER OPEN - EXCESSIVE
HALL EFFECT SIGNAL (active or stored), flash each PSD and/or PLG module(s) the vehicle is equipped with and reset obstacle detection values in
each module flashed.
NOTE:
DTC "INCOMPLETE LATCH RELEASE - SECTOR GEAR RETURN FAILURE" (ACTIVE OR STORED) MAY OR MAY NOT BE PRESENT
ALSO.
EQUIPMENT REQUIRED:
NOTE:THE MDS2 AND DRB III(R) ARE REQUIRED TO PERFORM PART OF THIS REPAIR. THE MDS2 SYSTEM MUST BE OPERATING
WITH CIS CD2118 OR HIGHER.
REPAIR PROCEDURE:
1.
Connect a battery charger and set as close to 14 volts charge as possible.
2.
Log onto the MDS2 System.
3.
Connect the MDS2 (Mopar Diagnostic System) and DRB III(R) (Scan Tool) to the vehicle and switch the ignition to "ON".
NOTE:
