Magnum V8-5.7L VIN H (2005)
Window Seal: All Technical Service Bulletins
Body - Door Glass Run Puckering Along B-Pillar
NUMBER: 23-018-04
GROUP: Body
DATE: May 18, 2004
SUBJECT:
Left Front Door Glass Run Distortion
OVERVIEW:
This bulletin involves seating the glass run in the B-pillar channel and possibly replacing the door glass.
MODELS:
2005
(LX)
300/Magnum
NOTE:
This bulletin applies to vehicles built prior to May 1, 2004 (MDH 0501XX).
SYMPTOM/CONDITION:
When the left front door glass is raised the outboard lip of glass run puckers along the B-pillar.
DIAGNOSIS:
Visually inspect the outboard lip of glass run with the glass in the full up position, if the glass run is puckered, perform the Repair Procedure.
PARTS REQUIRED:
REPAIR PROCEDURE:
1.
Lower glass to full down position.
2.
Push rubber glass run rearward to fully seat in B-pillar channel.
3.
Fold outer lip of glass run rearward into proper position.
4.
Cycle window up/down 6 to 8 times.
5.
If glass run puckers again, use the service procedures available on TechCONNECT to replace door glass.
NOTE:
Door Speaker removal is not required.
NOTE:
If the water shield gets torn during glass replacement, repair or replace the watershield.
POLICY:
Reimbursable within the provisions of the warranty.