RAM 1500 Van V8-5.2L VIN Y (1999)
Technical Service Bulletin # D20
Date: 040901
Recall - ABS Wiring Corrosion
September 2004
Dealer Service Instructions for:
Safety Recall D20 - ABS Wiring Corrosion
Models
1998-2003
(AB)
Dodge Ram Van/Wagon
NOTE:
This recall applies only to the above vehicles equipped with a 4-wheel Anti-lock Brake System (ABS) (sales code BGK).
IMPORTANT:
Some of the involved vehicles may be in dealer used vehicle inventory. Dealers should complete this recall service on these vehicles before retail
delivery. Dealers should also perform this recall on vehicles in for service. Involved vehicles can be determined by using the VIP inquiry process.
Subject
Electrolyte (battery acid) from aftermarket batteries may leak onto an Antilock Brake System (ABS) wiring connector on about 43,000 of the above
vehicles. This may cause the wiring to corrode and short circuit, which can result in an underhood fire.
Repair
All vehicles must have a revised battery tray installed that will protect the ABS control module wiring harness connector from future electrolyte leakage.
A cowl seal extension must also be installed on all vehicles to redirect any water draining from the windshield away from the battery.
The ABS control module wiring harness and connector must be inspected for electrolyte damage and repaired if necessary.