Shadow Convertible L4-153 2.5L SOHC (1994)
Hose/Line HVAC: All Technical Service Bulletins
A/C System - Poor Cooling Performance
NO: 24-15-94 Rev. A
GROUP: Heater & A/C
DATE: Nov. 25, 1994
SUBJECT:
Poor A/C Performance
THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 24-15-94 DATED OCT. 7, 1994 WHICH SHOULD BE REMOVED FROM
YOUR FILES. THE REVISION INCREASES THE TIME ALLOWANCE. ALL REVISIONS ARE HIGHLIGHTED WITH **ASTERISKS**.
MODELS:
1994 - 1995
(AA)
Spirit/Acclaim/LeBaron Sedan
1994 - 1995
(AJ)
LeBaron Convertible
1994
(AP)
Shadow/Shadow Convertible/Sundance
SYMPTOM/CONDITION:
Cooling performance of A/C system is poor.
DIAGNOSIS:
Check the refrigerant level and check for R-134a at the discharge and suction line connections of the A/C compressor using the procedures outlined on
Page 24-9 of the 1994 LeBaron, Spirit, Acclaim, Shadow and Sundance Service Manual (Publication No. 81-270-4101). If R-134a is found at the
discharge and/or suction line connections of the A/C compressor, perform the repair procedure.
PARTS REQUIRED:
1
3849730
Gasket, A/C Suction Line to Compressor
1
5264373
Gasket, A/C Discharge Line to Compressor
NOTE:
GASKET PART NUMBERS 4540158 AND 4540157 SHOULD NEVER BE USED ON VEHICLES EQUIPPED WITH R-134a REFRIGERANT
AS DETERIORATION OF THE SEALING CAPABILITIES WILL RESULT AND CAUSE REFRIGERANT TO ESCAPE.
REPAIR PROCEDURE:
This bulletin involves replacing the gaskets between A/C compressor and the discharge and suction lines. Replace both gaskets even if only one
connection is suspect.
1.
Recover any R-134a refrigerant in the A/C system.
2.
Disconnect the A/C discharge and suction lines from the A/C compressor and discard the gaskets.
3.
Install new gaskets, P/N 5264373 on the discharge line and P/N 3849730 on the suction line.
4.
Reconnect the A/C discharge and suction lines to the A/C compressor. Torque the fasteners to 180-220 in. lbs. (20-25 N-m).
5.
Evacuate and recharge the A/C system with R-134a refrigerant using the procedures outlined on Page 24-10 of the 1994 LeBaron, Spirit, Acclaim,
Shadow and Sundance Service Manual (Publication No. 81-270-4101).
POLICY:
Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
Labor Operation No:
24-45-41-90
**0.8 Hrs.**
FAILURE CODE: P8 - New Part
