Sprinter 3500 L5-2.7L DSL Turbo (2004)
Air Filter Element: Customer Interest
Engine, A/C - Idle Instability With Rear A/C ON
NUMBER: 24-001-09
GROUP: Heating & Air Conditioning
DATE: April 25, 2009
SUBJECT:
Idle Instability - Rear A/C Idle Cutout Module Installation
OVERVIEW:
This bulletin involves installing a Rear A/C cutout module and inspecting the engine air filter.
MODELS:
2003 - 2006
(VA)
Sprinter
NOTE:
This information applies to models equipped with Rear Air Conditioning
SYMPTOM/CONDITION:
Some customers may experience idle instability in warm temperatures while using the rear A/C system.
DISCUSSION:
A rear A/C cutoff kit is available to eliminate idle instability. The kit will temporarily turn the compressor off when nearing idle RPM and allow it to
operate normally while driving. Additionally, it is important that the engine can breath properly for proper performance and the Air Filter and housing
must be inspected for dirt.
PARTS REQUIRED:
SPECIAL TOOLS/EQUIPMENT REQUIRED:
REPAIR PROCEDURE:
1. Following the procedures listed in the parts kit Instruction Sheet, Install the Rear A/C cutout kit using the standard splice procedures listed below.
2. Inspect the air filter and housing. If the air filter is dirty, replace the filter and clean the housing of any debris.