Stealth R/T V6-2972cc 3.0L DOHC (1991)
The State of California requires the completion of emission recall repairs prior to vehicle registration renewal. In addition, the State requires that every
vehicle must pass an emission test (SMOG Check) every two years and before it is sold. Without the free service we are providing, your vehicle may be
more likely to fail this test and require that you make costly repairs.
Further, in order to ensure your full protection under the emission warranty provisions, it is recommended that you have your vehicle serviced as soon as
possible. Failure to do so could be determined as lack of proper maintenance of your vehicle.
WHAT WILL THE DEALER DO TO MY VEHICLE?
At no charge to you, the dealer will replace the evaporative canister.
HOW LONG WILL IT TAKE?
The service will take about one-half hour but additional time may be required depending on how service work is scheduled and processed.
HOW WILL THIS REPAIR AFFECT MY VEHICLE'S ENGINE PERFORMANCE AND FUEL ECONOMY?
The repair will not hurt your engine performance or fuel economy.
HOW CAN I OBTAIN THE REPAIR?
Contact your dealer to make an appointment for the free service.
Take the enclosed Owner Notification Form with you at the time of your appointment and give it to your dealer. The form identifies the vehicle and
recall for which service is required.
HOW WILL THE STATE KNOW THAT THE RECALL HAS BEEN PERFORMED ON MY VEHICLE?
State of California regulations require Chrysler to provide the Department of Motor Vehicles with a record of all vehicles which have not had the recall
service performed. If your vehicle is not on this list, the state will know that the recall has been completed.
Your dealer will provide you with a Vehicle Emission Recall Proof of Correction Form after the recall service is completed. Be sure to save this form
since the California Department of Motor Vehicles may require that you supply it as proof of recall completion.
WHAT IF I NO LONGER OWN THE VEHICLE?
Please let us know by filling out the prepaid and addressed Vehicle Disposition Form portion of the enclosed Owner Notification Form.
WHAT SHOULD I DO IF I HAVE TROUBLE OBTAINING THE FREE SERVICE?
If you experience any difficulty in obtaining the corrective service, please contact the Chrysler Customer Center by phone at (800) 853-1403. A
representative will take the necessary action to ensure prompt correction of your vehicle.
We regret any inconvenience this action may cause, but trust you understand our interest in clean air and in your continued satisfaction with our
products. Thank you for your prompt attention to this important matter.
Service Procedure
SERVICE PROCEDURE VIDEOTAPE
No videotape of the service procedure for this recall will be provided.
SERVICE PROCEDURE
A.
REPLACE EVAPORATIVE CANISTER:
1.
Remove the three coolant reserve bottle bolts and set the bottle aside.
2.
Disconnect the vapor and purge hoses from the evaporative canister which is located under the coolant bottle.
3.
Remove the two canister bracket bolts and discard the canister and bracket assembly.
4.
Install the supplied canister bracket using the provided bolts. Tighten to 8 ft lbs (12 Nm).
5.
Install the new canister in the bracket and connect the vapor and purge hoses.
Note:
