E 350 V10-6.8L (2007)
Brake Pad: Customer Interest
Brakes - Abnormal Rear Inner Brake Pad Wear
TSB 07-20-8
10/15/07
EARLY WEAR OF THE INNER BRAKE PAD ON THE
REAR DISC BRAKES
FORD:
2004-2007 E-250, E-350
This article supersedes TSB 07-17-1 to clarify vehicle coverage.
ISSUE
Some 2004-2007 E-Series 250/350 vehicles may exhibit early wear of the inner brake pad on the rear disc brakes when operated in mud, slush, dirt, or
other severe conditions. Full rear brake dust shield assemblies have been released for service.
ACTION
Refer to the Service Procedure to install two (2) rear brake dust shield assemblies.
SERVICE PROCEDURE
NOTE
THIS BULLETIN DOES NOT APPLY TO ROLL STABILITY CONTROL (RSC) IVD VEHICLES.
Refer to the appropriate E-Series Workshop Manual (WSM), Section 206-04 for service information.
NOTE
THE REAR BRAKE DUST SHIELD ASSEMBLIES ARE IDENTICAL FOR THE LEFT AND RIGHT SIDE. THE SERVICE PARTS ARE
DIFFERENT FOR VEHICLES BUILT PRIOR TO 11/29/2004.
NOTE
FOR E-350 SRW CUTAWAY VEHICLES ONLY PARTS ARE UNIQUE. THE PARTS ARE NOT INTERCHANGEABLE.
^
Shallow shields are available for dual rear wheel (DRW) with single rear wheel (SRW) axle and outboard rotors that are protected by the single rear
wheel.
^
Deep shields are available for SRW service - only for SRW axles with inboard rotors that are not protected by the single rear wheel.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
072008A
2004-2007 Econoline Full
3.5 Hrs.
Floating Axle: Install Brake
Dust Shield Assemblies
(Do Not Use with 2001B,
2001B1, 2001B5 2001B10
2780A, 4010A, 4234A)
