Expedition 4WD V8-5.4L SOHC VIN 5 (2005)
Evaporator Drain Tube: All Technical Service Bulletins
A/C - Water Leaks Onto Passenger Compartment Floor
TSB 05-8-7
05/02/05
WATER LEAK INTO PASSENGER COMPARTMENT
FLOOR AND/OR RATTLE NOISE FROM DASH
FORD:
2005 Expedition
LINCOLN:
2005 Navigator
ISSUE
Some 2005 Expedition/Navigator vehicles built 8/01/2004 through 1/17/2005, may exhibit a water (condensation) leak into the passenger compartment
floor and/or a rattle noise coming from the dash. This may be due to the evaporator case lower stud and nut being loose allowing water to seep past the
seal between the evaporator case and the drain tube.
ACTION
Tighten the nut that attaches the evaporator case to the stud to 42 lb-in (4.8 N.m) (Figure 1). Ensure that the case is tight to the drain tube seal. The case
stud and nut can be accessed from under the dash by pulling the carpet back on the passenger side floor.
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
OPERATION
DESCRIPTION
TIME
050807A
2005 Expedition/Navigator
0.2 Hr.
Tighten The Lower
Evaporator Case Stud
DEALER CODING
CONDITION
BASIC PART NO.
CODE
19B555
33
Disclaimer