Expedition 4WD V8-5.4L VIN 5 (2006)
PROM - Programmable Read Only Memory: All Technical Service Bulletins
Engine Controls - Hard Start/MIL ON/Multiple DTC's Set
TSB 06-13-9
07/10/06
HARD START, LOW POWER AT 3500 RPM, MIL ON
P0340, P0344, P0172, P0175 AND EXPEDITION
ONLY - IDLES TOO FAST COLD
FORD:
2005-2006 Expedition
LINCOLN:
2005-2006 Navigator
This article supersedes TSB 05-4-15 to update the vehicle model years.
ISSUE
Some 2005-2006 Expedition/Navigators may exhibit a hard start during multiple restart attempts or during hot soak restart attempts and / or the
malfunction indicator lamp (MIL) on with diagnostic trouble codes (DTCs) P0340, P0344, P0172, and / or P0175 and / or a reduction in power between
3500 and 4500 RPM during wide open throttle (WOT) application. Some customers may describe the condition as feeling like the transmission is
slipping, a lack of transmission upshift or a hesitation. 2005-2006 Expedition (only) may also exhibit a higher than normal idle on cold start.
ACTION
Follow normal diagnostics for the vehicle symptom(s) to determine if there is an actual physical issue with the fuel / ignition / exhaust systems and / or
base engine causing the symptom(s). If no issues are found during normal diagnostics and the symptoms still occur, reprogram the powertrain control
module (PCM) to the latest calibration using IDS Release B43.4 or later. Calibration files may also be obtained at the website.
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage And Emissions Warranty Coverage
OPERATION
DESCRIPTION
TIME
061309A
2005-2006
0.4 Hr.
Expedition/Navigator 5.4L
3V: Check Diagnostic
Trouble Codes And
Reprogram The Powertrain
Control Module (Do Not
Use With 12650D,
12650D84)
MT061309
Claim Additional Labor
Actual
Required As Actual Time
Time
Or Use SLTS Operation If
Available
DEALER CODING
CONDITION
BASIC PART NO.
CODE
RECALEM
04
Disclaimer