Explorer AWD V6-4.0L VIN K Flex Fuel (2003)
Wiring Harness: All Technical Service Bulletins
Audio System - Delayed Power When Switched ON
TSB 05-21-7
10/31/05
DELAYED RADIO POWER UP WHEN THE KEY IS
CYCLED ON
FORD:
2002-2003 Explorer
MERCURY:
2002-2003 Mountaineer
ISSUE
Some 2002-2003 Explorer 4dr and Mountaineer vehicles built after 3/4/2002 equipped with the 3L2T-18C815-FA CDx6-A Audiophile radio may
exhibit a delayed radio power up when the key is cycled on. The concern may last up to 23 seconds.
ACTION
If the concern is verified install a jumper harness and 2004 CD6 Audiophile radio. Refer to the following Service Procedure.
SERVICE PROCEDURE
1.
Remove the radio following the Workshop Manual, Section 415.
2.
Install the jumper harness between the 14401 dash harness and the new 2004 CD6 Audiophile radio.
3.
Install the radio unit per Workshop Manual, Section 415.
NOTE
WHEN INSTALLING THE RADIO, MAKE SURE ALL EXCESS HARNESS IS FED TO THE DRIVERS SIDE, BEHIND THE CLUSTER.
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
OPERATION
DESCRIPTION
TIME
052107A
2002-2003
0.3 Hr.
Explorer/Mountaineer:
Replace The Radio And
Install Jumper Harness (Do
Not Use With 18805b,
18805c)
DEALER CODING
CONDITION
BASIC PART NO.
CODE
18C815
01
OASIS CODES: 207000
Disclaimer
