Explorer Sport Trac 2WD V6-4.0L VIN E (2002)
3.
Remove the return line from the steering gear (Figure 5).
4.
Replace the current cooler (3D746) and two return lines (3A713 and 3A005) with a fin pack cooler assembly (5L2Z-3D746-A).
5.
Fill and purge the P/S system following the procedures called out in the on-line Workshop Manual Section 211-00.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
OPERATION
DESCRIPTION
TIME
051715A
2001 Explorer Sport Trac
2.2 Hrs.
4X214X4, Explorer Sport
4X214X4 Vehicles Built
Before 4-18-2001: Replace
The Power Steering Pump,
P/S Cooler, Install No Hole
Check Valve, Fill And
Purge The P/S System,
Reprogram The Powertrain
Control Module (Do Not
Use With 3504A, 3504A9,
3674A, 3674D)
051715A
2001-2002 Explorer Sport
2.2 Hrs.
Trac 4X4, Explorer Sport
4X214X4 Vehicles Built
After 4-18-01 And Before
11-7-2001: Replace The
Power Steering Pump, P/S
Cooler, Install No Hole
Check Valve, Fill And
Purge The P/S System,
Reprogram The Powertrain
Control Module (Do Not
Use With 3504A, 3504A9,
3674A, 3674D)
051715B
2001-2002 Explorer Sport
1.4 Hrs.
Trac 4X2 Built After
4-18-2001: Replace The
P/S Cooler, Install No Hole
Check Valve, Fill And
Purge The P/S System,
Reprogram The Powertrain
Control Module (Do Not
Use With 3504A, 3504A9,
3674A, 3674D)
051715C
2002-2005 Explorer Sport
1.0 Hr.
Trac 4X2/4X4 Explorer
Sport 4X2/4X4 Built After
11-7-2001: Replace The
P/S Cooler, Fill And Purge
The P/S System (Do Not