ford Workshop Repair Guides

Ford Workshop Service and Repair Manuals

Brakes - Warning Lamp ON/Leaks/Spongy Pedal|Page 5958 > < Bleeding After Caliper Replacement|Page 5949
Page 1
background image

Brake Caliper: Customer Interest
Brakes - Warning Lamp ON/Leaks/Spongy Pedal

Article No.
99-4-2

03/08/99

^

BRAKES - ILLUMINATION OF RED BRAKE 
WARNING LAMP - BRAKE FLUID LEAK FROM 
REAR CALIPER - VEHICLES BUILT THROUGH 
10/22/1998

^

BRAKES - INCREASED BRAKE PEDAL TRAVEL - 
BRAKE FLUID LEAK FROM REAR CALIPER - 
VEHICLES BUILT THROUGH 10/22/1998

^

BRAKES - SPONGY BRAKE PEDAL FEEL - BRAKE 
FLUID LEAK FROM REAR CALIPER - VEHICLES 
BUILT THROUGH 10/22/1998

^

LAMP - ILLUMINATION OF RED BRAKE WARNING 
LAMP - BRAKE FLUID LEAK FROM REAR 
CALIPER - VEHICLES BUILT THROUGH 10/22/1998

LIGHT TRUCK: 
1999 F-250 HD, F-350, F-450, F-550, SUPER DUTY F SERIES

NOTE

THIS TSB ARTICLE IS FOR 4X2 VEHICLES ONLY. OWNER NOTIFICATION PROGRAM (ONP) 98B32 WILL COVER 4X4 VEHICLES.

ISSUE
Customers may report a brake fluid leak at the left rear wheel which may result in a spongy brake pedal, increased pedal travel, and/or illumination of the
red brake warning lamp on some vehicles driven frequently on gravel roads or similarly severe conditions. This may be caused by a loose brake hose
connection at the left rear brake caliper. (This condition may also occur on the right rear brake caliper of F-550 vehicles built on or after 6/15/1998.) The
brake hose joint may lose clamp load and begin to leak due to stone impingement on the hose banjo block which may cause additional deformation of the
copper washers resulting in the reduction of clamp load and subsequent joint leak.

ACTION
Replace the current brake hose with a revised brake hose which is routed behind the rear axle and attach a metal stone shield onto the front face of brake
caliper. The rerouted brake hose is protected from damage by the rear axle tube. The metal stone shield mounted on the front face of the caliper protects
the hose banjo block from stone impingement to reduce the possibility of leaks. Refer to the Instruction Sheet included in the kit for installation
procedures.

Parts Block

OTHER APPLICABLE ARTICLES: NONE

WARRANTY STATUS: Eligible Under The Provisions Of Bumper To Bumper Warranty Coverage

OPERATION

DESCRIPTION

TIME

990402A

Replace Left Rear Brake

0.7 Hr.

Hose And Install Stone
Shield - F-250/350

Brakes - Warning Lamp ON/Leaks/Spongy Pedal|Page 5958 > < Bleeding After Caliper Replacement|Page 5949