F 350 2WD Pickup V8-6.9L DSL (1983)
Fuel Supply Line: Customer Interest
Fuel Hose - Stalling Due to Fuel Starvation
Article No. 83-8-15
STALLS DUE TO FUEL STARVATION (6.9L DIESEL) - FUEL HOSE KINKED BETWEEN SIDE RAIL AND WATER/FUEL SEPARATOR
LIGHT TRUCKS 1983 F-250/350
Fuel starvation on 6.9L diesel vehicles may be the result of a kink in the flexible fuel hoses between the left side frame rail and the water/fuel separator.
To eliminate any kinks in the flexible fuel hoses, the following service procedure should be used:
CAUTION: DO NOT SERVICE BY SHORTENING THE HOSE IF A KINK IS PRESENT.
FIGURE 15
^
Route water separator fuel hoses from the water separator inlet-outlet nipples inboard of the water separator protective shield in
front of the wiring harness, and to the rear of the speedometer cable and hydraulic clutch hose (Figure 15).
^
A minimum of 2" clearance must be provided between the water separator hoses and the steering column.
OTHER APPLICABLE ARTICLES: None
WARRANTY STATUS: Reimbursable within the provisions of the Warranty and Policy Manual.
OPERATION: M
TIME:
"Actual Time" as defined in the Warranty and Policy Manual. DLR. CODING: Basic Part No. 9324 Code: 43