Five Hundred AWD V6-3.0L VIN 1 (2005)
DOOR LATCH GREASING - ALL VEHICLES
NOTE:
This operation is to be performed on all four (4) door latches of all affected vehicles.
NOTE:
A single syringe of latch grease contains enough material for one (1) vehicle. The syringe is marked indicating the amount of grease to be applied to
each door latch.
1.
Remove the door latch upper screw located toward the outside of the door. See Figure 6.
2.
Fully insert the tip of the syringe into the screw hole and apply approximately one (1) unit of grease (one graduation mark on the syringe). See
Figure 7.
3.
Wipe away any excess grease then reinstall the latch screw. Tighten the screw to 12 Nm (9 lb-ft).
REAR DOOR REPAIR - FREESTYLE ONLY
1.
Completely lower both rear windows.
