Focus ZX5 L4-2.0L DOHC VIN 3 (2002)
DOOR LATCH CLEANING AND LUBRICATION
WARNING:
SAFETY GLASSES OR GOGGLES ARE REQUIRED WHILE PERFORMING THIS PROCEDURE.
NOTE:
This procedure is to be performed on all four (4) doors including those with replacement latches.
1.
Open the door, then using a screwdriver, fully close the door latch (two clicks). See Figure 4.
2.
Shake the can of Door Latch and Lock Lubricant for 10-15 seconds.
3.
WARNING: SAFETY GLASSES OR GOGGLES ARE REQUIRED WHILE PERFORMING THIS PROCEDURE.
NOTE:
A single can of Door Latch and Lock Lubricant contains enough material for one (1) vehicle.
Spray each latch mechanism for 5 to 10 seconds.
Spray the Door Latch and Lock Lubricant into the square opening shown in Figure 6.
4.
Open the latch using either the inside or outside door handle.
5.
Cycle the door (close then open the door) 5-10 times to allow the lubricant to circulate around the latch mechanism.
6.
Wipe the latch and surrounding area, including the striker, of any excess lubricant.
7.
Using a screwdriver, fully close the door latch (two clicks). See Figure 4.