Mustang V8-5.4L SC (2008)
5.
Adjust the door glass so that the door glass is flush to the quarter glass division bar or outboard of the division bar by no more than 1/16" (2 mm).
(Figure 6). Use the door glass window regulator jack screw to adjust glass outboard. Remove the round reflector located at the bottom of the door
trim panel. Turning the jack screw clockwise tips the glass outboard, counterclockwise tips the glass inward. If additional adjustment is needed,
then remove trim panel and use glass clamps. Refer to WSM, Section 501-11.
NOTE
MISALIGNED DOOR GLASS WILL BOUNCE BACK DURING OPERATION IF IT CONTACTS THE INBOARD SIDE OF THE UPPER
CONVERTIBLE SEAL RETAINER. CONCERN MAY BE DUPLICATED WITH TOP UP AND REAR WINDOWS DOWN. DOOR GLASS
MUST BE ALIGNED TO BOTH THE CONVERTIBLE TOP AND QUARTER GLASS DIVISION BAR.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION
DESCRIPTION
TIME
081703A
2005-2009 Mustang
0.7 Hr.
Convertible: Replace One
Rear Quarter Glass And
Adjust. (Do Not Use With
29710A)
081703B
2005-2009 Mustang
1.3 Hrs.
Convertible: Replace Both
Rear Quarter Glass And
Adjust. (Do Not Use With
29710A)
081703C
2005-2009 Mustang
1.4 Hrs.
Convertible: Replace One
Rear Quarter Glass And
Adjust, Additional
Adjustment Is Needed
Remove Interior Door Trim
Panel. (Do Not Use With
23943A, 23943A13,
29710A)
081703D
2005-2009 Mustang
2.6 Hrs.
Convertible: Replace Both
Rear Quarter Glass And
Adjust, Additional
Adjustment Is Needed