Ranger 2WD V6-182 3.0L (1995)
Compressor Clutch: Customer Interest
A/C - Little or No Cooling
Article No.
94-23-9
11/14/94
AIR CONDITIONING - LITTLE OR NO COOLING - FS-10 COMPRESSORS - EXCESSIVE CLUTCH AIR GAP - ALL ENGINES EXCEPT 1.8L
ESCORT/TRACER AND 3.0L, 3.2L SHO - VEHICLES BUILT THROUGH 9/19/94
FORD:
1995 CONTOUR, CROWN VICTORIA, ESCORT, MUSTANG, TAURUS, THUNDERBIRD
LINCOLN-MERCURY:
1995 CONTINENTAL, COUGAR, GRAND MARQUIS, MARK VIII, MYSTIQUE, SABLE, TOWN CAR, TRACER
LIGHT TRUCK:
1995 AEROSTAR, BRONCO, ECONOLINE, EXPLORER, F-150-350 SERIES, RANGER, VILLAGER, WINDSTAR
ISSUE:
About 6500 1995 vehicles with factory installed A/C may have a short thread in the FS-10 A/C compressor shaft that holds the clutch bolt. The bolt
could bottom out and leave a gap between the the bolt head and the clutch disc. This could lead to the clutch disc moving away from the pulley resulting
in an excessive air gap which could prevent the A/C clutch from engaging.
ACTION:
If this condition exists, adjust the air gap according to the service procedures found in Section 12-00 of the appropriate Service Manual and install clutch
spacer(s) under the head of the clutch bolt as a washer. The largest spacer is approximately 1 mm thick and can be found in spacer pack
(F1VY-19D648-A).
PART NUMBER
PART NAME
CLASS
F1VY-19D648-A
Spacer Pack
A
OTHER APPLICABLE ARTICLES: NONE
WARRANTY STATUS:
Eligible Under The Provisions Of Bumper To Bumper Warranty Coverage
OPERATION
DESCRIPTION
TIME
942309A
Adjust Air Gap
0.3 Hr.
DEALER CODING
BASIC PART NO.
CONDITION CODE
19D648
79
OASIS CODES: 208000, 208200, 208999
