Taurus V6-182 3.0L (1987)
Oxygen Sensor: All Technical Service Bulletins
O2 Sensor Wiring Chafing - Electrical Malfunctions
^
GLASS - HEATED BACKLITE INOPERATIVE -
Article No.
3.0L - WITH AIR CONDITIONING - 12A581
87-11-1
WIRE HARNESS CHAFING
^
LAMP - TURN SIGNALS INOPERATIVE - 3.0L -
WITH AIR CONDITIONING - 12A581 WIRE HARNESS CHAFING
^
RUNS RICH - 3.0L - WITH AIR CONDITIONING -
12A581 WIRE HARNESS CHAFING
FORD:
1986-87 TAURUS
LINCOLN-MERCURY: 1986-87 SABLE
ISSUE:
Inoperative turn signals, inoperative heated backlite or vehicles that run rich may be caused by the heated exhaust gas oxygen (HEGO) sensor
wiring chafing against the air conditioning compressor or pinching between the air conditioning compressor and support bracket. The
damaged HEGO wiring results in a blown #5 fuse.
ACTION:
To correct this, install a piece of protective convolute tubing and install a new #5 fuse using the following diagnostic service procedure.
Figure 1 - Article 87-11-1
1.
Locate the wire for the HEGO sensor at the front of the engine, Figure 1.
NOTE:
If wires have convolute tubing completely covering them and are not pinched between the air conditioning compressor and support
bracket, further inspection is not required. Perform normal diagnostic procedure.
2.
If damaged wires are found, repair as required.
3.
Install convolute tubing (D4SZ-14A099-F) on HEGO wiring, butting one end against HEGO connector and wrap both ends with electrical tape,
Figure 1.
4.
Replace the blown #5 fuse (D9ZZ-14526-D).
5.
Check turn signals and heated backlite for proper operation.
PART NUMBER
PART NAME
CLASS
D4SZ-14A099-F
Convolute Tubing
C
D9ZZ-14526-D
Fuse - 15 Amp
AM
OTHER APPLICABLE ARTICLES: None
WARRANTY STATUS: Reimbursable within the provisions of the Warranty and Policy Manual
OPERATION: SP871101A
TIME:
0.6 Hr.
DLR. CODING: Basic Part No. 12A581 - Code: 46
