Taurus V6-183 3.0L VIN U FI (1993)
Suspension Spring ( Coil / Leaf ): All Technical Service Bulletins
Front Suspension - Grunt/Popping Noise While Turning
Article No.
93-14-11
07/07/93
NOISE - "GRUNT/POPPING" HEARD DURING LOW SPEED TURNING MANEUVERS - VEHICLES BUILT BEFORE 3/15/93.
FORD:
1991-93 TAURUS
LINCOLN-MERCURY:
1991-93 SABLE
ISSUE:
A "grunt/popping" noise coming from the front suspension at low speeds, below 20 MPH (32 KM/H) when turning, may be caused by contact between
the rubber coated outer rim of the upper spring seat bearing assembly (3K028) and the underside of the shock tower sheet metal. Colder weather could
result in this rubbing noise being more noticeable.
ACTION:
If service is required, use the following procedure based on the model and powertrain application.
DIAGNOSIS FOR ALL TAURUS AND SABLE MODELS - EXCEPT SHO
1.
Determine if vehicle ride height is at or below specified height.
2.
Park the vehicle on a level surface with a full tank of gas. If less than a full tank is available, use the adjustment factors shown in the following
Fuel Fill Adjustment Factor Chart.
3.
Set tires to decal pressure.
4.
Neutralize the vehicle's suspension system.
a.
Push on the roof rail above the driver's door laterally so as to cause the vehicle to roll.
b.
Use about five (5) or six (6) pushes to provide sufficient roll to settle the vehicle out in a neutralized state.
