Tempo L4-122 2.0L DSL (1984)
Diesel MFI Pump: Technical Service Bulletins
Injector Pump - Low Power/Excessive Smoke
Article No. 84-19-8
FUEL INJECTION - SHOP MANUAL REVISION - INJECTION PUMP TIMING
FORD 1984-85 ESCORT, TEMPO 2.0L DIESEL
LINCOLN-MERCURY 1984-85 LYNX, TOPAZ 2.0L DIESEL
The following pages on injection pump timing procedure should be utilized when diagnosing a condition of insufficient engine power and excessive
smoke, and/or excessive engine noise.
OTHER APPLICABLE ARTICLES: None
WARRANTY STATUS: "INFORMATION ONLY"
Setting Injection Timing Dynamic
FIGURE A - CLEANING LOCATION
1.
Completely clean the indicated portion of No. 1 high pressure fuel line (Figure A).
2.
Install pressure transducer around No. 1 high pressure fuel line at position indicated (Figure A).
NOTE:
Be sure entire contact surface of pressure transducer contacts fuel line. If not, replace pressure transducer.
FIGURE B - PRESSURE TRANSDUCER INSTALLATION
3.
Tighten pressure transducer clamp thumbscrew only enough to insure stability.