Prizm L4-108 1.8L DOHC VIN 8 MFI (1995)
Owners will be notified of this campaign on their vehicles by Chevrolet Motor Division (see copy of owner letter included with this bulletin).
DEALER CAMPAIGN RESPONSIBILITY
All unsold new vehicles in dealers, possession and subject to this campaign must be held and inspected/repaired per the service procedure of this
campaign bulletin before owners take possession of these vehicles.
Dealers are to service all vehicles subject to this campaign at no charge to owners, regardless of mileage, age of vehicle, or ownership, from this time
forward.
Owners of vehicles recently sold from your new vehicle inventory with no owner information indicated on the dealer listing, are to be contacted by the
dealer, and arrangements made to make the required correction according to the instructions contained in this bulletin. This could be done by mailing to
such owners a copy of the owners letter accompanying this bulletin. Campaign follow-up cards should not be used for this purpose, since the owner may
not as yet have received the notification letter.
In summary, whenever a vehicle subject to this campaign enters your vehicle inventory, or is in your dealership for service in the future, please take the
steps necessary to be sure the campaign correction has been made before selling or releasing the vehicle.
Service Procedure
CAUTION:
WORK ON THE SUPPLEMENTAL INFLATABLE RESTRAINT SYSTEM (SIR) MUST NOT START FOR 90 SECONDS FOLLOWING THE
NEGATIVE BATTERY CABLE DISCONNECTION, THE SIR SYSTEM HAS A BACK-UP POWER SOURCE WHICH MAY CAUSE
INADVERTENT DEPLOYMENT IF WORK IS STARTED WITHIN THE FIRST 90 SECONDS.
Inspection
1.
Note electronic settings before disconnecting negative battery cable from battery and wait a minimum of 90 seconds before proceeding.
2.
Remove 2 screws securing center console to rear center console.
3.
Remove tray liner and screws underneath tray liner.
4.
Raise parking brake lever and remove console.
5.
Remove 3 bolts securing console mounting bracket to floor. Remove bracket.
