Envoy 2WD V8-5.3L VIN P (2004)
16. Remove the rear seats.
17. Remove the headliner harness retaining clips (2) from the rocker panel and floor panel.
18. Remove the center pillar headliner harness electrical connector from the bussed electrical center, and the block base from the floor panel.
19. Reach underneath the carpet and remove the headliner harness electrical connector (1) from the IP wire harness.
20. Disconnect the inside rear view mirror electrical connector (6).
21. Disconnect the rain sensor electrical connector, if equipped.
22. Disconnect the navigation antenna electrical connector, if equipped.
23. Remove the upper rear quarter trim panels.
24. Remove the coat hooks from the roof panel.
25. Remove the 2 push pins from the rear of the headliner.
26. Release the assist handles from the roof panel.
27. Fully recline the bucket seats.
28. With the aid of an assistant, release the interlocking strips (1) that retain the headliner to the roof panel.
29. If the vehicle is equipped with a sunroof, partially lower the headliner and disconnect the sunroof assembly electrical connector.
30. With the aid of an assistant, remove the headliner from the vehicle.
Installation Procedure
1. With the aid of an assistant, install the headliner into the vehicle.
