K 2500 Truck 4WD V8-393 6.5L DSL Turbo (1992)
Vehicle Speed Sensor: All Technical Service Bulletins
Constant or Intermittent MIL ON, No DTC's Set
BULLETIN NUMBER:
93-7A-13
SECTION:
7A
NUMBER:
2
CORPORATE
REFERENCE NUMBER:
277138
DATE:
October 1992
SUBJECT:
CONSTANT OR INTERMITTENT CHECK ENGINE LIGHT (DIAGNOSE PER LH6 CHART)
MODELS:
1991-93 C/K, R/V, P TRUCKS AND G-VAN
CONDITION:
Some 1991-93 trucks equipped with the L65 6.5 Turbo Diesel or the LL4 6.2 Diesel and 4L80-E/4L80-EHD exhibit a constant or intermittent check
engine light with the engine running and no codes stored.
CAUSE:
The 4L8O-E/4L80-EHD use an engine speed sensor and if failure occurs a code will not be stored. Code 12 will be present with the engine running and
the ALDL grounded. The electronic transmission control section of the 1991, 1992 and 1993 service manuals does not acknowledge the use of an engine
speed sensor or code 12 for the L65 (6.5 turbo) or the LL4 (6.2) electronic transmission applications.
CORRECTION:
Check for proper engine speed sensor operation as follows:
1991 and 1992 Vehicles
For diagnosis, use the code 12 chart from the LH6 Diesel Emission Section of the 1991 or 1992 Service Manual (Pages 6E2-22 and 6E2-23). When
following the trouble tree, substitute TCM PIN D7 for ECM PIN C1 and TCM PIN D6 for ECM PIN A8.
1993 Vehicles
For diagnosis, use the code 12 chart from the LH6 Diesel Emission Section of the 1993 Service Manual (Pages 6E2-22 and 6E2-23 for the G Van, Pages
6E2-32 and 6E2-33 for the C and K vehicles). When following the trouble tree, substitute TCM PIN D7 for PCM PIN F5 and TCM PIN D6 for PCM
PIN F4.
