Savana 1/2 Ton Van V8-5.7L VIN R (2001)
Fan Clutch: All Technical Service Bulletins
Engine - Loud Roaring/Whining Noise
File In Section: 06 Engine/Propulsion System
Bulletin No.: 02-06-02-002
Date: May, 2002
Subject:
Loud Whine or Roar Noise From Engine
(Replace Cooling Fan Clutch)
Models:
2001-2002 Chevrolet and GMC G-Van Models
with 5.7L Gas Engine (VIN R -- RPO L31)
Built Prior to March, 2002
Condition
Some customers may comment on an unusual engine noise, usually described as a loud whine or roar, when the vehicle is first started. The noise is more
noticeable in cold temperatures and goes away after the vehicle warms up.
Cause
The cooling fan clutch rotates at a speed lower than engine RPM except when exposed to cold temperatures. The viscosity of the clutch fluid is increased
or the flow of the clutch fluid is decreased in cold weather. This causes the fan to rotate at a higher RPM than normal and causes noticeable noise in the
engine compartment. After several minutes of vehicle operation, the clutch begins to work and slows the fan, therefore reducing the noise.
Correction
A new cooling fan clutch, P/N 88986801, is available to correct this condition. Replace the cooling fan clutch following the service procedure in the
Engine Cooling sub-section of the Service Manual.
Parts Information
Parts are currently available from GMSPO.
Warranty Information
For vehicles repaired under warranty, use the table.
Disclaimer
