Savana 3500 V8-4.8L (2009)
Door Stop: Customer Interest
Door - RH Swing-Out Door Contacting Front Passenger Door
TECHNICAL
Bulletin No.: 10-08-64-001A
Date: April 11, 2011
Subject: Right Side Intermediate Swing-Out Door (60 Door) Contacting Front Passenger Door (Install 60 Door Check Strap Bumper)
Models:
2004-2012 Chevrolet Express
2004-2012 GMC Savana
With RPO E24
Supercede:
This bulletin is being revised to add model years. Please discard Corporate Bulletin Number 10-08-64-001 (Section 08 - Body & Accessories).
Condition
Some customers may comment that the right side 60 door is making contact with the front passenger door, when both doors are open. They may also
comment on seeing dents on the right side 60 door outer panel.
Cause
This condition may be caused by the right side 60 door over-traveling its intended opening angle.
Correction
Limit the door travel by adding a check strap bumper (referenced below) to the 60 door check strap following the steps below:
1. Open the right side 60 door far enough to access the check strap (1).
2. To disengage the strap from the door, pull and hold the strap rearward (away from the stop pin inside the door) while opening the door towards its
full open position, approximately 170 degrees.
