Savana 4500 V8-6.6L DSL Turbo (2009)
1. Apply a mild soap and water solution to the right rear door weatherstrip.
2. Start at the bottom of the channel in the door and slide the right rear door weatherstrip up the channel to the top of the door.
3. Install the right rear door weatherstrip to the top of the door. Use GM Weatherstrip Adhesive GM P/N 12345097, (Canadian P/N 10953479) or the
equivalent, if you are reusing the weatherstrip.
4. Press the retainers in the right rear door weatherstrip into the holes in the door until fully seated.
Rear Door Wedge Replacement
Rear Door Wedge Replacement
Removal Procedure
1. Remove the bolts that retain the rear door wedge to the door.
2. Remove the rear door wedge from the door.
Installation Procedure
1. Install the rear door wedge to the door.
Caution: Refer to Fastener Caution (See: Service Precautions/Vehicle Damage Warnings/Fastener Caution).
2. Install the rear door wedge bolts in order to retain the rear door wedge to the door and tighten to 10 Nm (89 lb in).
Rear Side Door Lower Weatherstrip Replacement
Rear Side Door Lower Weatherstrip Replacement