Sierra 3500 2WD V8-6.0L (2008)
Technical Service Bulletin # 09184A
Date: 091026
Campaign - Possible Air-Bag Deployment/Servce Light ON
CUSTOMER SATISFACTION
Bulletin No.: 09184A
Date: October 26, 2009
Subject: 09184A - Material Over Sensing and Diagnostic Module Retaining Moisture
Models:
2007-2009 Chevrolet Silverado
2007-2009 GMC Sierra
Currently or Previously Registered in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan,
Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, , West Virginia, Wisconsin
Supercede:
This bulletin has been revised to include an inspection procedure and a new labor code. Vehicles with vinyl flooring and no cutout flap require no repair.
All technicians are to review the new inspection procedure immediately. Please discard all copies of bulletin 09184, issued October 2009.
Condition
Certain 2007-2009 model year Chevrolet Silverado and GMC Sierra vehicles currently or previously registered in Connecticut, Delaware, District of
Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio,
Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin may have a condition where an electronic component located beneath the driver's
seat may corrode due to a significant quantity of snow and/or water containing road salt or other contaminants entering the vehicle and saturating the
acoustical padding beneath the carpet. The vehicle's electronic sensing and diagnostic module (SDM) is located underneath this acoustical padding. If
sufficient moisture collects and is retained in the padding, it may cause excessive corrosion under the module; compromising the module seal and
allowing water intrusion and system malfunction. This may result in illumination of the Airbag Readiness light, along with a "Service Airbag" message
on the Driver Information Center, and in rare cases, deployment of the seat belt pretensioner and/or airbags.
Correction
Dealers are to remove the acoustical pad above the SDM.
Vehicles Involved
Involved are certain 2007-2009 model year Chevrolet Silverado and GMC Sierra vehicles currently or previously registered in Connecticut, Delaware,
District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New
York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin, and built within these VIN breakpoints: