S2000 L4-1997cc 2.0L DOHC (VTEC) MFI (2001)
Convertible Top Latch: All Technical Service Bulletins
Body - Convertible Top Creaks/Pops or Rattles
03-023
October 9, 2006
*Applies To:
2000-07 S2000 - ALL*
Convertible Top Creaks, Pops, or Rattles While Driving Over Rough Roads (Supersedes 03-023, dated April 1, 2003, to update the information marked
by the black bars and asterisks)
SYMPTOM
The convertible top creaks, pops, or rattles while driving over rough roads. This noise is only noticeable with the top raised and the driver's and
passengers windows closed.
PROBABLE CAUSE
This noise can be the result of any of these causes:
^
Gaps between the mounting bracket and the plastic trim of the convertible top lock handles
^
Various weatherstrip pieces and plastic parts are rubbing on the convertible top frame
^
Dry pivot points on the convertible top frame
CORRECTIVE ACTION
Add EPT sealer to the lock handles, and lubricate the indicated areas.
REQUIRED MATERIALS
Shin-Etsu Silicone Grease:
P/N 08798-9013, H/C 4642294
(One tube repairs about 25 vehicles.)
White Lithium Grease:
P/N 08732-0005, H/C 2963718
(One can repairs about 25 vehicles.)
NOTE:
Make sure you use white lithium grease in the aerosol can. It has special solvents that allow deep penetration into small areas of the joint to
effectively dampen any noise caused by movement. It also sets up quickly to form a thick coating as the carrier gas evaporates. Other grease or
application methods do not work as well.
EPT Sealer (3T):
P/N 06990-5A5-000, H/C 2086643
(One roll repairs about 100 vehicles.)
WARRANTY CLAIM INFORMATION
*In warranty:
The normal warranty applies.*