i-350 L5-3.5L (2006)
Seat Cover: Technical Service Bulletins
Interior - Interior Surface Cleaning
Bulletin No.: IB07-11-S014
Issue Date: December 2007
Affected Vehicles:
2006-2008 Isuzu Ascender
2007-2008 Isuzu i-290/i-370 (TI)
2006 Isuzu i-280/i-350 (TI)
Service Information
This bulletin is being revised to update model years and Service Information.
To keep the vehicle interior looking the best it should be cleaned often. It is important to keep the upholstery from becoming heavily soiled. The
vehicle's interior can experience extreme heat which can cause stains to set quickly. Lighter color interiors may require more frequent cleaning. Care
should be taken because newspapers and garments may transfer color to the vehicle's interior.
Many of today's interiors are made with new low gloss materials. Permanent damage may result from using cleaners on ANY surfaces (interior trim,
instrument panel, carpet, leather, vinyl, and fabric) for which they are not intended. Using non-approved products can actually set the stain so that
nothing can remove it
Important:
^
Do not use silicone or wax-based products or those containing organic solvents (such as naptha, alcohol, etc.) to clean your vehicle's interior
because they can alter the appearance by increasing the gloss in a non-uniform manner. The increase in gloss may cause annoying reflections in
the windshield and even make it difficult to see through the windshield under certain conditions.
^
never use a STIFF brush or a brush that has been previously used with a harsh chemical, This can cause damage to the vehicle's interior surfaces.
^
Use only mild, Neutral-pH cleaners. Avoid laundry detergents or dishwashing soaps with degreasers. Using too much soap will leave residue that
leaves streaks and attracts dirt.
Because it is critical to use only mild neutral-pH cleaners use the cleaners and conditioners listed in this bulletin for the cleaning of interiors. These
products are in the neutral-pH range and will maintain the best vehicle interior appearance. These products are water-based biodegradable and do not
contain bleach solvents or harsh chemicals.
Interior trim pieces on new vehicles as well as service components arrive with a protective film. When removing the protective film adhesive residue
may be left on the trim panels/components. The cleaner (for leather vinyl plastic and interior paint) is an effective cleaner in removing adhesive residue
without causing damage to the component.
Important:
^
If soapy, alkaline cleaning solutions are used on fabrics, and not throughly rinsed out, the residual left in the fabric will attract dirt. Because the
recommended cleaners/conditioners are in the pH neutral range, they won't leave behind soapy residue.
^
On heavily stained or difficult to clean fabric/carpet, it is recommended that the entire surface be treated and cleaned vs. spot cleaning.
Effective cleaning steps for hard and/or plastic surfaces:
1.
Using a clean towel apply/spray cleaner - leather vinyl plastic interior paint directly onto the towel.
2.
Wipe the surface with the towel/cleaner.
3.
If necessary use a soft bristle brush to work cleaner into the crevasses of the area being cleaned.
4.
Wipe off any excess cleaner from the surface.
5.
Using a clean towel apply/spray the conditioner (leather vinyl restorer) directly onto the towel.
6.
Wipe the conditioner onto the previously cleaned area to restore the material to its original luster.
Important:
Today's interior's are developed and intended to have a low-gloss appearance. It is important to use only products which provide a low-gloss
finish in order to maintain the interior's integrity, customer appeal and satisfaction.
