XJ (X350) V8-4.2L (2005)
Air Spring: All Technical Service Bulletins
Suspension - Lower Than Normal After Being Parked
NUMBER: JTB00067
(ISSUE 1)
MODEL:
XJ
DATE: 3 DEC 2007
THIS BULLETIN REPLACES XJ204-06, ISSUED 03/2005. AS THE CHANGES ARE EXTENSIVE, THEY ARE NOT HIGHLIGHTED IN GRAY.
SECTION: 204-05
Air Suspension System - Diagnosis
AFFECTED VEHICLE RANGE:
XJ (X350)
VIN:
G00442 - Onwards
Model Year:
2004 - Onwards
CONDITION SUMMARY:
AIR SUSPENSION SYSTEM LEAK DIAGNOSIS
Situation:
A lower than normal suspension system after being parked for several hours or concerns about air spring leakage may be caused by air leakage from a
component or connection in the air suspension system.
Action:
Should a customer express the above concern, follow the Diagnostic Procedure outlined below to set the air suspension system to a known
condition so measurements can be taken.
PARTS:
NOTE:
GOTEC LDS is a shop supply and is not to be claimed for this procedure.
C2C 22398...............GOTEC LDS (Leak Detection Spray)
As required
TOOLS:
Jaguar IDS and DVD 109 Patch File 3 or later
204-484....................Ride Height Gauge
WARRANTY:
NOTE:
Repair procedures are under constant review, and therefore times are subject to change; those quoted here must be taken as guidance only. Always
refer to DDW to obtain the latest repair time.
DDW requires the use of causal part numbers. Labor only claims must show the causal part number with a quantity of zero.
DIAGNOSTIC PROCEDURE
AIR SUSPENSION SYSTEM LEAK INSPECTION
1.
Park the vehicle on level ground with the ignition switched 'OFF', the steering in the straight ahead position and the transmission selector lever in
'PARK'.
CAUTION:
This procedure requires IDS DVD109 with Patch file 3 or later and the Midtronics PSC-550 Vehicle Power Supply connected to the vehicle
battery during diagnosis.