XK-8 Convertible (X100) V8-4.0L (AJ26) (1997)
Hose/Line HVAC: All Technical Service Bulletins
A/C system - Low Pressure Hose Rubs Through
412-02
DATE
8/97
XK8
MODEL
1997 MY
XK8 Range
VIN
001036-011462
A/C Low Pressure Hose - Interference With EGR Pipe - Service Action S 820
Issue:
On XK8 vehicles within the VIN range 001036-011462, interference can occur between the A/C low pressure hose at the rear of the engine and the EGR
pipe, which in extreme conditions could lead to rupture of the hose and the loss of the refrigerant gas charge.
The concern can be eliminated by installing a special heat resistant tie strap to improve the retention of the hose as described in this bulletin.
Action:
Modify all stock vehicles within the above VIN range. In the case of vehicles already in service, perform the modification at the next service visit.
In case the A/C hose has ruptured due to the condition described above, claim the hose replacement and system recharging through normal warranty
procedures. Secure the new hose with the special heat resistant tie strap as described in the bulletin.
MODIFYING A/C HOSE RETENTION
1.
Release and open the hood and install fender covers.
2.
After removing the two retaining bolts, move the air intake duct away from the throttle body to provide access.
3.
Disconnect the vacuum hose from the cruise control actuator.
4.
Install the special high-temperature specification tie strap as indicated in Illustration 1, by passing the tie strap around the body of the 55-way
connector and around the low pressure hose, adjacent to the flange of the EGR pipe.