Grand Cherokee 2WD V8-318 5.2L VIN Y MFI (1994)
2.
Slowly close the door until the striker loop contacts the latch (See Figure 1). Mark the location where the rearward side of the latch rachet contacts
the striker loop. Open the door and measure the clearance as shown in Figure 1. The clearance should be from 8 to 10 mm. (5/16 to 3/8 in.). If the
proper clearance is not attained shim adjustment is required. The chart in Figure 1 has been provided to show the thickness of the various shim
combinations.
NOTE:
DO NOT EXCEED THE MAXIMUM SHIM THICKNESS SPECIFIED IN THE CHART. THE COMBINATION OF 1 GOLD AND 1 SILVER
SHIM IS THE MAXIMUM THICKNESS ALLOWED FOR PROPER THREAD ENGAGEMENT. DO NOT USE TWO GOLD SHIMS OR USE
MORE THAN TWO SHIMS IN COMBINATION.
3.
Loosen the striker screws and add or subtract shims using the chart to obtain the correct latch to striker contact.
4.
Align the striker height centering the striker in the latch opening as shown in Figure 2 and position it inboard or outboard to make the door flush,
5.
Tighten the screws to 30 Nm (250 in.lbs.).
POLICY: Reimbursable within the provisions of the warranty.
TIME ALLOWANCE: Latch Lock, Rt. Front Door - Replace (Inc. Adjustment)
Labor Operation No:
23-41-02-90
0.5 Hrs.
Latch Lock, Lt. Front Door - Replace (Inc. Adjustment)
23-41-02-91
0.5 Hrs.
Latch Lock, Rt. Rear Door - Replace (Inc. Adjustment)
23-41-02-92
0.5 Hrs.
Latch Lock, Lt. Rear Door - Replace (Inc. Adjustment)
23-41-02-93
0.5 Hrs.
Striker, Door Latch - Adjustment Only
23-41-02-94
0.2 Hrs.
FAILURE CODE:
P8 - New Part
Technical Service Bulletin # 237093
Date: 931217
Door Lock/Latch - Inoperative
NO.: 23-70-93
GROUP: Body
DATE: Dec. 17, 1993
SUBJECT:
Door and Latch Operation
MODELS:
1993 - 1994 (ZJ) Grand Cherokee/Grand Wagoneer
SYMPTOM/CONDITION:
Door lock or latch inoperative. See specific details below.
DIAGNOSIS:
If any of the locks or door latches do not work, check the symptoms listed below and perform the repairs indicated.
REPAIR PROCEDURE:
This bulletin involves performing adjustments to the door latch and lock mechanism.
CONDITION 1:
The left front power door lock switch or keyless remote will not unlock any of the remaining side doors. If this condition exists, one or more of the
following procedures will be required:
