Grand Cherokee 2WD V8-5.7L VIN 2 (2005)
Window Track: All Technical Service Bulletins
Body - Door Glass Sticks/Binds/Loose/Tracks Poorly/Noise
NUMBER: 23-023-05
GROUP: Body
DATE: April 19, 2005
SUBJECT:
Door Glass - Loose, Sticks, Binds, Tracks Poorly, And/Or Causes A Moan-Like Sound
OVERVIEW:
This bulletin involves inspecting and correcting several possible door glass issues.
MODELS:
2005
(WK/WH)
Grand Cherokee
NOTE:
This bulletin applies to vehicles built prior to May 01, 2005 (MDH 0501Xx).
SYMPTOM/CONDITION:
The customer may experience one or more of the following door glass conditions:
^
Moan-like sound when the door glass is in operation. This condition occurs when the glass is moved downward. This condition may be due to the
door inner belt line molding - secondary (lower) seal. The secondary seal may turn under as the glass moves downward.
^
Door glass sticks, track poorly, pivots, or falls down inside door. This condition may be due to the glass not being installed correctly to the window
regulator clamps.
^
Door glass binds or tracks poorly. This condition may be due to the glass not being properly adjusted to the door or loose window hardware.
DIAGNOSIS:
If one or more of the above conditions are present, perform the Repair Procedure to the specific door that has the condition(s).
PARTS REQUIRED:
NOTE:
The plastic retainers used to attach the door trim panel to the inner door panel must be replaced each time the door trim panel is removed.
REPAIR PROCEDURE:
1.
Disconnect and isolate the negative battery cable from the battery.